Get one of these—the kind with the round stamped-steel "hat", like this:
Attachment:
Screen Shot 2023-03-25 at 16.19.33.jpg [ 83.03 KiB | Viewed 5536 times ]
| Slant Six Forum https://slantsix.org/forum/ |
|
| Fuel Pump Problem and Options https://slantsix.org/forum/viewtopic.php?t=67157 |
Page 1 of 1 |
| Author: | 64 Convert [ Fri Mar 24, 2023 5:56 pm ] |
| Post subject: | Fuel Pump Problem and Options |
The last few times I drove my '64 Valiant 225, the oil pressure light flckered at idle when warm. With less than 10k on the engine, I ruled out engine wear, so my first guess was a bad sender. However, when I looked under the car, I saw a few drips from the fuel pump area. Since there was an unusual buildup of oil in the drip pan, I checked the dipstick and found the engine was overfilled about two quarts. I fear that my fuel pump has been pumping gas into the crankcase, and I now have some drastically diluted oil! I only found one Carter pump on RockAuto, so I'm guessing my choice is down to one, and I suppose it is made in China. Does anyone make a high-quality mechanical pump, or should I be considering an electric pump? If so, any suggestions? Comments? |
|
| Author: | SlantSixDan [ Sat Mar 25, 2023 4:20 pm ] |
| Post subject: | Re: Fuel Pump Problem and Options |
Get one of these—the kind with the round stamped-steel "hat", like this: Attachment: Screen Shot 2023-03-25 at 16.19.33.jpg [ 83.03 KiB | Viewed 5536 times ] |
|
| Author: | Rick Covalt [ Sat Mar 25, 2023 4:57 pm ] |
| Post subject: | Re: Fuel Pump Problem and Options |
Hey Dan, thanks for the info!  Most of the new ones are absolute junk and the fittings twist and leak and are just like they are made of tin foil. Anyway, my question is about whether or not there will be any problems with the AC ones that look to be 20-30 year old stuff? Will the diaphragms still be Okay in them? Thanks again!
|
|
| Author: | SlantSixDan [ Sat Mar 25, 2023 5:03 pm ] |
| Post subject: | Re: Fuel Pump Problem and Options |
I never had to re-replace one after installing it, even after pulling it out of a well-worn old box, even well into the gasohol era. It's possible you could have an early failure, but early failure is practically guaranteed with today's Chinese lumps of fuel pump-shaped garbage. |
|
| Author: | 64 Convert [ Sun Mar 26, 2023 4:09 am ] |
| Post subject: | Re: Fuel Pump Problem and Options |
Thanks for your help again, Dan. I ordered one and it's on the way. |
|
| Author: | Greg Ondayko [ Sun Mar 26, 2023 12:57 pm ] |
| Post subject: | Re: Fuel Pump Problem and Options |
Pump shaped garbage I love it.!! |
|
| Page 1 of 1 | All times are UTC-07:00 |
| Powered by phpBB® Forum Software © phpBB Limited https://www.phpbb.com/ |
|